Product ID:TT-P-645 ZINC CHROMATE PRIMER Z/C YELLOW/STEEL/ALUM
MSDS Date:06/13/1996
FSC:8010
NIIN:00F052963
MSDS Number: CDQVT

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700/800-255-3924

Info Phone: 201-438-3700/800-255-3924

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

CHROMIUM, CHROMIUM METAL, CHROME (CARCINOGEN BY NTP; IARC

CAS: 7440-47-3

RTECS: GB4200000

Fraction By Weight: 10%

ACGIH TLV: 0.5 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

POTASSIUM ZINC CHROMATE (CONFIRMED HUMAN CARCINOGEN BY

CAS: 11103-86-9

RTECS: GA9170000

Fraction By Weight: 20%

OSHA PEL 0.01 MG/CUM (CRO3)

ACGIH TLV: 0.01 MG/CUM (CR)

ALKYD RESIN

Fraction By Weight: 5%

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30-50%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:MAY HAVE CNS EFFECTS, INCLUDING DEATH.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:RASH, SCALING, BLISTERING, HEADACHES,
DIZZINESS, ANESTHETIC
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. SKIN:
FLUSH W/WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:104F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:CO2, DRY CHEMICAL FOAM
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. DON'T USE WATER
HOSE STREAM. WEAR FULL BUNKER GEAR (HELMET W/FACE SHIELD, BUNKER
COAT, GLOVES, RUBBER BOOTS.)
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS & OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE DUE
TO EXTREME HEAT. (SUPP)

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS, FLAMES & ANYTHING WHICH COULD CAUSE
FIRE. ELIMINATE SOURCE OF SPILL, IF IT CAN BE DONE W/O RISK BY
CLOSING VALVE, PLUGGING HOL E. APPLY INERT MATERIAL.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN EMPTIED.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR TYPES SUITABLE.
APPROVED CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION
IS RESTRICTED. PRECAUTIONS MUST BE TAKEN SO THAT PERSONS DON'T
BREATHE VAPORS/HAVE CON TACT W/EYES/SKIN. (SUPP)
Ventilation:SUFFICIENT, IN VOLUME & PATTERN, SHOULD BE PROVIDED TO KEEP
AIR CONTAMINATION BELOW APPLICABLE LIMITS.
Protective Gloves:RECOMMENDED
Eye Protection:CHEMICAL GOGGLES W/SIDESHIELD/FACESHIELD
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE: WATER MAY BE USED TO COOL CLOSED CONTIANERS. EVACUATE
AREA. VAPOR IS HEAVIER THAN AIR & MAY TRAVEL LONG DISTANCES TO
SOURCE OF IGNITION. RESPIRATORY: PROTECT AGAINST EXPOSURE TO VAPOR
& SPRAY MIST. VENTILATION: SOLVENT VAPORSSHOULD BE REMOVED FROM
LOWER LEVELS & IGNITION SOURCES SHOULD BE ELIMINATED.

Boiling Pt:B.P. Text:305-410F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN YELLOW LIQUID W/TYPICAL SOLVENT ODOR
Percent Volatiles by Volume:49.2

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS & ALKALIES
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:SOAK LIQUIDS W/SAWDUST/RAGS & REMOVE. FLUSH
W/WATER IF POSSIBLE. DON'T INCINERATE, CUT/WELD EMPTY CONTAINERS.
DISCARD AS HAZARDOUS WASTE. TRANSFER LIQUID TO CONTAINERS FOR
RECOVERY/DISPOSAL. DISPOSE O F IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.